IPS CORP -- WELD-ON 707 FOR PVC PLASTIC PIPE  -- 8040-00N043541
<pre>=====================  Product Identification  =====================

Product ID:WELD-ON 707 FOR PVC PLASTIC PIPE
MSDS Date:04/01/1992
FSC:8040
NIIN:00N043541
=== Responsible Party ===
Company Name:IPS CORP
Address:17109 S MAIN ST
Box:379
City:GARDENA
State:CA
ZIP:90248
Country:US
Info Phone Num:213-321-6515
Emergency Phone Num:213-222-3212;800-424-9300(CHEMTREC)
CAGE:EO483
=== Contractor Identification ===
Company Name:IPS CORP
Address:17109 S MAIN
Box:379
City:GARDENA
State:CA
ZIP:90248-5000
Country:US
Phone:213-321-6515/213484-5151
CAGE:EO483
Company Name:IPS CORPORATION
Address:17109 S. MAIN ST.,
Box:379
City:GARDENA
State:CA
ZIP:90248
Country:US
Phone:310-898-3300
CAGE:17510

=============  Composition/Information on Ingredients  =============

Ingred Name:POLYVINYL CHLORIDE RESIN (PVC)
OSHA PEL:N/K 
ACGIH TLV:N/K 

Ingred Name:FURAN, TETRAHYDRO-; (TETRAHYDROFURAN) (THF) (SARA III)  BP:
    151F, 66C.	VP: 143 @ 20C
CAS:109-99-9
RTECS #:LU5950000
Fraction by Wt: 25-35%
OSHA PEL:200 PPM; 250 STEL
ACGIH TLV:200 PPM; 250 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (MEK)  (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 55%
OSHA PEL:200 PPM; 300 STEL
ACGIH TLV:200 PPM; 300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:CYCLOHEXANONE  (SARA III)
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 1-10%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:VOLATILE ORGANIC COMPOUNDS: 750 G/L. MORE THAN 60% ACTS AS
    REACTIVE DILUENT & REMAINS IN JOINT.
RTECS #:9999999VO
OSHA PEL:N/K 
ACGIH TLV:N/K 

Ingred Name:HNDLG/STOR PREC:AVOID CNTCT W/EYES, SKIN & CLTHG.
RTECS #:9999999ZZ

Ingred Name:RESP PROT:EMER & OTHER CNDTNS WHERE SHORT TERM EXPOS
    GUIDELINES MAY BE EXCEEDED, USE NIOSH/MSHA APPRVD POS PRESS SCBA.
RTECS #:9999999ZZ

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:SEV OVERXP MAY RSLT IN
    NAUS, DIZZ, HDCH. CAN CAUSE DROW, IRRIT OF EYES & NASAL PASSAGES.
    SKIN CNTCT: IRRIT. LIQ CNTCT MAY REMOVE NATURAL SKIN OILS RSLTG IN
    IRRIT. DERM MAY OCCUR W/PRLNG CN TCT. PRLNG/WIDESPREAD EXPOS MAY
    RSLT INABSORPTION OF HARMFUL AMTS MATL. EYES:SEV EYE INJURY WITH
    (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CORNEAL/CONJUCTIVAL INFLAM ON CNTCT
    W/LIQ. VAPS SLIGHTLY UNCOMFORTABLE. INGEST:MOD TOX. MAY CAUSE NAUS,
    VOMIT, DIARR. MAY CAUSE MENTAL SLUGGISHNESS. CHRONIC:SYMPS OF RESP
    TRACT IRRIT & DMG TO  RESP EPITHELLUM REPORTED IN RATS EXPOSTO
    5000PPM THF FOR 90 DAYS. ELEVATION OF SGPT SUGGEST DISTURBANCE IN
    (SUPDAT)
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
    DISEASES OF THE EYES, SKIN OR RESPIRATORY SYSTEM MAY HAVE INCREASED
    SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE EXPOSURES.

=======================  First Aid Measures  =======================

First Aid:INHAL:IF OVERCOME BY VAPS, REMOVE TO FRESH AIR & IF BRTHG
    STOPPED, GIVE ARTF RESP. IF BRTHG DFCLT, GIVE OXYGEN. CALL MD.
    EYES:FLUSH EYES W/PLENTY WATER FOR @ LEAST 15 MIN & CALL MD. SKIN:
    REMOVE CONTA MD CLTHG & SHOES. WASH SKIN W/PLENTY SOAP & WATER FOR
    @ LEAST 15 MIN. IF IRRIT DEVELOPS, GET MED ATTN. INGEST:GIVE 1 OR 2
    GLASSES WATER/ MILK. DO NOT INDUCE VOMIT. CALL MD/POIS CTL CTR.

=====================  Fire Fighting Measures  =====================

Flash Point Method:TCC
Flash Point:6F,-14C (THF)
Lower Limits:2%
Upper Limits:11.8%
Extinguishing Media:ANSUL "PURPLE K" POTASSIUM BICARBONATE DRY CHEM,
    CO2, NATL AER-O-FOAM UNIVERSAL ALCOHOL RESISTANT FOAM, WATER SPRAY.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
    EVACUATE ENCLSD AREAS, STAY UPWIND. USE WATER SPRAY TO COOL CNTNRS,
    TO FLUSH SPILLS FROM SOURCE OF (SUPDAT)
Unusual Fire/Explosion Hazard:FIRE HAZARD BECAUSE OF LOW FLASH POINT &
    HIGH VOLATILITY. VAPORS ARE HEAVIER THAN AIR & MAY TRAVEL TO SOURCE
    OF IGNITION.

==================  Accidental Release Measures  ==================

Spill Release Procedures:ELIM ALL IGNIT SOURCES. AVOID BRTHG VAPS. KEEP
    LIQ OUT OF EYES. FLUSH W/LG AMT WATER. CONTAIN LIQ W/SAND/EARTH.
    ABSORB W/SAND/NONFLAMM ABSORB MATL & TRANSFER INTO STEEL DRUMS FOR
    RECOVERY/DISP. PVNT L IQ FROM ENTERING DRAINS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:STORE IN SHADE BETWEEN 40F-110F. KEEP
    AWAY FROM HEAT, SPARKS, OPEN FLAME & OTHER SOURCES OF IGNIT. AVOID
    PRLNG BRTHG OF VAP. USE W/ADEQ VENT. (ING 6)
Other Precautions:FOLLOW ALL PRECAUTIONARY INFORMATION GIVEN ON CNTNR
    LABEL, PROD BULLETINS & MFR SOLV CEMENTING LITERATURE. ALL HNDLG
    EQUIP SHOULD BE ELEC GROUNDED. TRAIN EMPLOYEES ON ALL SPECIAL HNDLG
    PROC BEFORE BEF ORE THEY WORK W/THIS PRODUCT.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:ATM LEVELS SHOULD BE < ESTABLISHED EXPOS LIM. IF
    AIRBORNE CONC EXCEED LIMS, NIOSH/MSHA APPRVD ORG VAP CARTRIDGE RESP
    W/FULL FCPIECE RECOM. EFTIVENESS OF AIR PURIFYING RESP IS LIMITED.
    USE IT ONLY FOR  SINGLE SHORT-TERM EXPOS. FOR (ING 7)
Ventilation:USE W/ADEQ VENT. PROVIDE SUFFICIENT VENT IN VOL & PATTERN
    TO KEEP CONTAM < EXPOS LIM. USE ONLY EXPLO PROOF VENT EQUIP.
Protective Gloves:PVA COATED GLOVES.
Eye Protection:CHEM SAFETY GOGG & FULL FCSHIELD .
Other Protective Equipment:IMPERVIOUS APRON & SOURCE OF RUNNING WATER
    TO FLUSH/WASH EYES & SKIN IN CASE OF CONTACT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPEC GRAV:TYPICAL 0.920 +/- 0.040 @ 73F +/- 2. SOL IN H2O:SOLV PORTION
    COMPLETELY SOLUBLE; RESIN PORTION SEPARATES OUT. FIRE FIGHT
    PROC:IGNIT & TO DISPERSE VAPS. EFTS OF OVEREXP:LIVER FUNC. NOEL
    REPOR TED TO BE 200PPM.

==================  Physical/Chemical Properties  ==================

HCC:F3
Boiling Pt:B.P. Text:ING 2
Vapor Pres:ING 2
Vapor Density:2.49
Spec Gravity:SUPDAT
Evaporation Rate &amp; Reference:>1.0 (BUAC=1)
Solubility in Water:SUPDAT
Appearance and Odor:GRAY OR CLEAR, MEDIUM SYRUPY LIQUID, ETHEREAL ODOR.
Percent Volatiles by Volume:80-90

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
CAUSTICS, AMMONIA, INORGANIC ACIDS, CHLORINATED COMPOUNDS, STRONG
    OXIDIZERS & ISOCYNATES.
Stability Condition to Avoid:KEEP AWAY FROM HEAT, SPARKS, OPEN FLAME
    AND OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:WHEN FORCED TO BURN, THIS PRODUCT
    GIVES OUT CARBON MONOXIDE, CARBON DIOXIDE, HYDROGEN CHLORIDE &
    SMOKE.

====================  Disposal Considerations  ====================

Waste Disposal Methods:FOLLOW LOCAL, STATE & FEDERAL REGULATIONS.
    CONSULT DISPOSAL EXPERT. CAN BE DISPOSED OF BY INCINERATION.
    EXCESSIVE QUANTITIES SHOULD NOT BE PERMITTED TO ENTER DRAINS. EMPTY
    CONTAINERS SHOULD BE AIR DRI ED BEFORE DISPOSING. HAZARDOUS WASTE
    CODE: 214.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.